WATCH YOUR STEP SLIPS TRIPS AND FALLS IN

WATCH YOUR STEP SLIPS, TRIPS, AND FALLS IN AGRICULTURE

Learning Objectives • Look at the injury statistics • Know the contributing factors, types of falls, and types of injuries • Make yourself aware of prevention strategies • Recognize slip, trip, fall hazards on the farm /workplace

Fall Statistics • One of the most frequent types of injury incidents – 2 nd to motor vehicle collisions • Over one million people suffer from a fall each year in the workplace • Annually – 300, 000 disabling injuries – 1, 400 Deaths

Types of Injuries • 20% of falls result in multiple body part injuries and the rest include isolated body part injuries • Common Injuries – – – Sprains Fractures Bruises Concussions Soreness and Pain

How Falls Happen • Same level falls – Slips: Losing traction between footwear and walking surface – Trips: Foot collides with object causing a lose of balance • Falls from an elevated surface

Contributing Factors • Poor housekeeping and lots of clutter • Poor lighting in walkways and work areas • Carrying oversized object that obstruct vision • Wearing the wrong footwear • Walking too fast or running • Distractions • Not paying attention

Same Level Falls • More Frequent • Usually Less Severe • Weather, liquids and chemical spills can all contribute to slips on walking surfaces • Trips can also occur when you don’t see an object or surfaces are uneven

Same Level Fall Hazards on the Farm • • • Manure in feed lots, pens, or isles Muddy conditions or loose gravel Loose hay Spilled grain Fresh oil spills or grease Working in low level light conditions • Uneven surfaces or rough terrain • Severe weather: ice, snow, rain

Elevated Falls • Elevated – Occur less often – More severe than same level falls • 60% occur at 10 ft or less above walking / working surface • Falls from vehicles, loading docks, equipment, ladders, buildings, and other elevated structures

Elevated surfaces on the Farm • Haymow or lofts • Below ground pits or open trenches • Loading docks • Bank barns • Equipment platforms / surfaces • Grain bins or silos • Steps / ladders

Methods to Prevent Falls • • Keep floors dry and clean Remove clutter Clean livestock pens regularly Remove dirt, mud and debris from surfaces Mark permanent isles or travel paths Inspect the farm regularly for fall hazards Train employees Schedule maintenance

Working in Changing Weather Conditions • Use proper footwear • Take short steps or shuffle, and try to ensure your torso stays balanced over your feet • Keep your hands out of your pockets • Utilize handrails, grab bars, fence line or solid object for stability • Create a secondary travel path • Use caution around livestock watering areas

Methods for Elevated Surfaces • • • Proper Housekeeping Well designed traffic patterns Be aware of changes in surface elevation Provide adequate lighting in work areas Utilize railings for surface changes over 4 feet in height • Cover floor openings when not in use • Always be cautious and alert to surroundings

Portable Ladders • Use only approved American National Standard Institute step and extension ladders • Should be set at a 4: 1 ratio between height and distance from the wall • Make surfaces are level and solid • Ensure no damage to the ladder before mounting • Extension ladders should extend 3 rungs above elevated surface • Never stand on top step of a step ladder

Farm Vehicles & Equipment • Don’t allow extra riders • Observe safety rules in owners manual • Make sure equipment is shut off and in park before dismounting • Keep surfaces clean and dry • Check for uneven ground when dismounting from last step

Farm Vehicles & Equipment • Face the equipment when mounting or dismounting • Use three points of contact when mounting or dismounting • Never jump off of steps • Ensure steps, hand holds, and railing are in good condition • Avoid trying to carry objects when mounting or dismounting

Protection Devices • At high elevations protective devices should be used • Proper devices include – – Cages / Rest Platform Lifeline Lanyard Safety Harness Safety belt & limit line • Device should ensure maximum protection without restricting work

Recognize the hazard

Recognize the hazard Hay Barn: Snow and ice Loose hay Extension cord across travel path Changing light conditions

Recognize the hazard

Recognize the hazard Feed lot: Snow, ice, and frozen manure Variety of elevation changes Contrast in light and shadows

Recognize the hazard

Recognize the hazard Hay Loft: Multiple obstructions getting on and off ladder. Loose hay of floor Loose or uneven floor boards Changes in light causing shadows

Recognize the hazard

Recognize the hazard Unloading Grain: Loose grain on ground. Changes in elevation with the ramp. Tools laying against the auger. Potential to fall into auger

Summary • Slips and Falls are sources of the most common injuries on a farm. • Take necessary steps to reduce hazards. • Know your farm and the hazards that exist. • It’s important to properly train workers.

References • Coping with Slips, Trips, and Falls in Farming Enterprises – http: //www. aces. edu/pubs/docs/A/ANR-1269. pdf • Ladders, Lifting and Falls – http: //www. umext. maine. edu/onlinepubs/PDFpubs/2326. pdf • Preventing Work Place Falls – http: //www. pubs. ext. vt. edu/3307 -1593/3307 -1593_pdf. pdf

For More Information OSU Ag Safety & Health The Ohio State University Ag Engineering Building 590 Woody Hayes Drive Columbus, Ohio 43210 -1057 Email: jepsen. 4@osu. edu Phone: 614 -292 -6008 Website: agsafety. osu. edu

THIS PROJECT WAS SUPPORTED BY THE USDA’S NATIONAL INSTITUTE OF FOOD AND AGRICULTURE (NIFA) RURAL HEALTH AND SAFETY EDUCATION GRANT PROGRAM- GRANT NUMBER 2012 -46100 -20144.