European Aviation Safety Agency Workshop EASA PartM aircraft

European Aviation Safety Agency Workshop EASA Part-M (aircraft not involved in Commercial Air Transport) Cologne 1 December 2006 Juan Anton Cologne 1

1. General Cologne 2

European Aviation Safety Agency REGULATION ORGANISATIONAL STRUCTURE Cologne 3

European Aviation Safety Agency EASA: Rulemaking Status of EASA texts Applicability; basic principles and essential requirements: Q Binding; adopted by the legislator under co-decision; included in Regulation Implementing Rules: Q Binding; will be adopted by the Commission following an Opinion from the Agency Guidance Material: Q Not binding; adopted by the Agency. Cologne 4

2. Part-M Cologne 5

European Aviation Safety Agency Regulation 2042/2003 Annex I (Part-M) Entry into Force Article 7(3)(a) to Commission Regulation 2042/2003 establishes that, Member States may elect not to apply the provisions of Annex I (Part-M) to aircraft not involved in commercial air transport, until 28 September 2008. See Opt-Out table: (http: //www. easa. europa. eu, Rulemaking, Opt-outs to regulation) Cologne 6

European Aviation Safety Agency Structure of Annex I (Part-M) to Regulation 2042/2003 Sections A&B Part-M Section A This section establishes the measures to be taken to ensure that airworthiness is maintained. It specifies the conditions to be met by persons or organisations involved in such continuing airworthiness management or maintenance organizations for general aviation. Part-M Section B This section establishes Administrative requirements to by followed by the competent authorities in charge of the application and enforcement of Section A. Cologne 7

European Aviation Safety Agency Who is the Competent Authority (Paragraph M. 1) For the purpose of Part-M, the competent authority shall be: For the oversight of the continuing airworthiness of individual aircraft and the issue of airworthiness review certificates the authority designated by the Member State of Registry. For the approval of maintenance programmes, the authority designated by the Member State of Registry. For the approval and oversight of maintenance organisations (Subpart F) and CAMO (Subpart G and I) the authority designated by the Member State where they are located, except those based in a third country. In this case, it will be EASA. Cologne 8

European Aviation Safety Agency Responsabilities of the owner and Subcontracting (M. A. 201) ¬The owner is responsible for the continuing airworthiness of the aircraft and shall ensure that: ¬ The aircraft is maintained in an airworthy condition; ¬ Any operational and emergency equipment fitted is correctly installed and serviceable; ¬ The airworthiness certificate remains valid; ¬ The maintenance of the aircraft is performed in accordance with the approved maintenance programme. ¬The owner is responsible for granting the competent authority access to the aircraft to determine continuing compliance with Part-M. Cologne 9

European Aviation Safety Agency Responsabilities of the owner and Subcontracting (M. A. 201) cont’d. ¬ The owner may contract: ¬ The tasks associated with continuing airworthiness to an approved continuing airworthiness management organisation (CAMO). In this case, the CAMO assumes responsibility for the proper accomplishment of these tasks. ¬ The maintenance to an approved maintenance organisation ¬ However, for large aircraft and for operators requiring an operational certificate (other than Commercial Air Transport), the contract with the CAMO and with an approved maintenance organisation is mandatory. The Contract with the CAMO will comply with Appendix I. Cologne 10

European Aviation Safety Agency Responsibilities of the pilot in command (M. A. 201) ¬The pilot in command shall be responsible for the satisfactory accomplishment of the “pre-flight inspection”. The inspection must be carried out by the pilot or another qualified person but need not be carried out by an approved maintenance organisation or by a Part-66 certifying staff. Pre-flight inspection is intended to mean all the actions necessary to ensure that the aircraft is fit to make the intended flight (see AMC M. A. 301 -1). Cologne 11

European Aviation Safety Agency Maintenance Programme (M. A. 302) Every aircraft shall be maintained in accordance with a “maintenance programme” approved by the competent authority. It must be reviewed and amended accordingly. When the aircraft continuing airworthiness is managed by a CAMO the maintenance programme and its amendments may be approved through a maintenance programme procedure established by such organisation (indirect approval). The procedure must be approved by the authority. Cologne 12

European Aviation Safety Agency Maintenance Programme (M. A. 302) The maintenance programme must be established in compliance with: TC holder recommendation Q This only requires copying TC holder information but could induce extra costs. NAA recommendations Q This will allow all existing national practices to continue, such as LAMS (Light Aircraft Maintenance Schedule) in the UK or AC extending piston engine overhaul limits. Instructions defined by the owner Q The owner may define himself other time limits acceptable to the NAA. This will allow practices in force in certain countries to continue in a more formalised manner. Cologne 13

European Aviation Safety Agency Modifications and Repairs (M. A. 304) Modifications and repairs must be approved according to Part-21. EASA will work on publishing standards practices manuals that will alleviate this requirement for the simple cases. These documents will initially be based on FAA AC 43. 13. Cologne 14

European Aviation Safety Agency Aircraft continuing airworthiness records (M. A. 305) For general aviation the existing system of log books satisfies the intent of this paragraph, as far as the airworthiness records are concerned. Cologne 15

European Aviation Safety Agency Maintenance Standards/Maintenance Data (M. A. 401) ¬ The person or organisation maintaining the aircraft shall have access to and use only applicable maintenance data in the performance of maintenance including modifications and repairs. ¬ Maintenance data is: ¬ Any applicable requirement, procedure, standard or information issued by the competent authority or the Agency. This allows national systems to continue and enable EASA to produce standards. ¬ Any applicable airworthiness directive; ¬ Applicable instructions for continuing airworthiness, issued by type certificate holders, STC holders and any other organisation that issues data in accordance with Part 21. Cologne 16

European Aviation Safety Agency Maintenance Standards/Performance of Maintenance (M. A. 402) All maintenance shall be performed by qualified personnel, following the methods, techniques, standards and instructions specified in the Maintenance data. PART-66 LICENCE IS NOT ALWAYS NEEDED ¬All maintenance shall be performed using the tools, equipment and material specified in the maintenance data. OWNERSHIP OF THE TOOLS IS NOT NEEDED ¬The area in which maintenance is carried out shall be well organised and clean in respect of dirt and contaminations. OWNERSHIP OF A HANGAR IS NOT NEEDED Cologne 17

European Aviation Safety Agency Subpart E Components A Decision is very close to publication to declare as standards parts all non required equipment on gliders. Non salvageable parts must be mutilated beyond repair before they are disposed of. This is important to limit the number of bogus parts. Maintenance on components must be performed by Subpart F or Part 145 organisations. However, certifying staff qualified in accordance with M. A. 801(b)(2) may perform maintenance on components while they are installed on the aircraft. Cologne 18

European Aviation Safety Agency Subpart F Maintenance Organisation ¬A maintenance organisation may maintain any aircraft and or component which it is approved at the locations specified in the approval certificate. ¬Alleviations for general aviation: ¬ No quality system. Organisational Reviews are allowed per M. A. 616. ¬ No ownership of tools, data and facilities. Cologne 19

European Aviation Safety Agency Subpart G Continuing Airworthiness Management Organisation (CAMO) An approved continuing airworthiness management organisation may manage the continuing airworthiness of non-commercial air transport aircraft as listed on the approval certificate. The CAMO may be authorised to approved the maintenance programme itself. The CAMO may be approved to issue the airworthiness review certificate. Alleviations for general aviation: ¬ No quality system needed if no ARC privilege is held (for small organisations) ¬ No ownership of data and facilities Cologne 20

European Aviation Safety Agency Certificate of Release to Service (CRS) M. A. 801 A certificate of release to service shall be issued before flight at the completion of any maintenance by: A Part-145 organisation; A Subpart F organisation; A Part-66 licensed engineer for non-complex tasks (see Appendix VII), excluding components off the aircraft; For gliders and ballons this means a national license. A Pilot-owner (per Appendix VIII) Tasks included in the AFM are not considered “maintenance tasks”, except in those cases where there is an attachment to the AFM showing the maintenance schedule. Cologne 21

European Aviation Safety Agency Certificate of Release to Service (CRS) by the pilot-owner (M. A. 803) The pilot-owner is the person who owns or jointly owns the aircraft being maintained and holds a valid pilot license with the appropriate type or class rating. For any privately operated aircraft of simple design with a maximum take-off mass of less than 2730 Kg, glider and balloon, the pilot-owner may issue the certificate of release to service after limited pilot owner maintenance listed in Appendix VIII to Part-M. The limited pilot-owner maintenance shall be defined in the aircraft maintenance programme. Cologne 22

European Aviation Safety Agency Certificate of Release to Service (CRS) by the pilot-owner (M. A. 803) cont’d For a pilot-owner a certificate of release to service should contain the following statement: « Certifies that the limited pilot-owner maintenance except as otherwise specified was carried out in accordance with Part-M and in respect to that work the aircraft is considered ready for release to service » Cologne 23

European Aviation Safety Agency Airworthiness Review Certificate (ARC) ¬ To ensure the continued airworthiness of an aircraft an airworthiness review must be carried out periodically. This airworthiness review includes a review of technical documentation and the physical survey of the aircraft. ¬ When an aircraft is continuously managed and maintained by approved organisations this activity is carried out without the intervention of the NAA. ¬ When an aircraft is not in the above case the ARC is issued by the NAA based on a recommendation from a CAMO, every year. Cologne 24

3. Significant Rulemaking Tasks Cologne 25

European Aviation Safety Agency M. 005: Pilot Owner Maintenance Re-evaluation of M. A. 803 and Appendix VIII. Evaluate interface between Appendix VIII „Limited Pilot Owner Maintenance“ and Appendix VII „Complex Maintenance Tasks“. Will incorporate the intent of Task M. 010 regarding Pilot Owner Maintenance in the case of collectively owned aircrafts in flying clubs. NPA to be published by 2 Q 2007. Opinion / Decision to be published by 2 Q 2008. Cologne 26

European Aviation Safety Agency M. 007: Part M amendment for noncommercial air transport. Regulatory Impact Assessment performed by Air Euro. Safe to evaluate the impact of Part M. Concern was limited to non-commercial air transport. NPA 07/2005 published on June 2005, with 5 months consultation period. CRD and Opinion / Decision will be issued by M. 017 Task. Cologne 27

European Aviation Safety Agency M. 017: EC 2042/2003 amendment for non -complex non-commercial aircrafts. Takes over the review of comments from NPA 07/2005 (M. 007). Implements the necessary changes to EC 2042/2003 as a result of MDM. 032. Includes changes not only to Part-M but to other Annexes (Part-66). NPA to be published by 1 Q 2007. Opinion / Decision to be published by 1 Q 2008. Cologne 28

European Aviation Safety Agency MDM. 032: A concept for better regulation in General Aviation Implies changes to regulations related to Initial Airworthiness, Continuing Airworthiness and Maintenance, Air Operations and Pilot Licensing. Changes to Continuing Airworthiness and Maintenance are handled by M. 017 group. Cologne 29

European Aviation Safety Agency THANK YOU FOR YOUR ATTENTION. www. easa. europa. eu (new address) Cologne 30